東華大學圖書館 |

Language: English

Help

回圖書館首頁

手機版館藏查詢

Back

Switch To: Labeled | MARC Mode | ISBD

Characterization of hydrodynamic for...

Hu, Weiwei.

Linked to FindBook

Google Book

Amazon

博客來

Characterization of hydrodynamic forces and interfacial phenomena in cell culture processes.

Record Type:	Language materials, printed : Monograph/item
Title/Author:	Characterization of hydrodynamic forces and interfacial phenomena in cell culture processes./
Author:	Hu, Weiwei.
Description:	176 p.
Notes:	Adviser: Jeffrey J. Chalmers.
Contained By:	Dissertation Abstracts International67-12B.
Subject:	Biology, Cell. -
Online resource:	http://pqdd.sinica.edu.tw/twdaoapp/servlet/advanced?query=3244807

Characterization of hydrodynamic forces and interfacial phenomena in cell culture processes.
Hu, Weiwei.

Characterization of hydrodynamic forces and interfacial phenomena in cell culture processes. - 176 p.

Adviser: Jeffrey J. Chalmers.

Thesis (Ph.D.)--The Ohio State University, 2007.

The maturity of biotechnology as a significant, commercial enterprise has led to the large scale production of products from a variety of cell types, including bacterial, fungal, mammalian, and microalgae. While both large scale (>10,000 L) mammalian cell culture and microalgae culture are currently used for commercial purposes, there still exist significant engineering challenges. One of these challenges is to quantify, and minimize, the effect of hydrodynamic forces on cells, which is in direct conflict with the ever pressing need to increase gas mass transfer capability and mixing performance of large scale bioreactors to improve productivity.Subjects--Topical Terms:

1017686
Biology, Cell.

Characterization of hydrodynamic forces and interfacial phenomena in cell culture processes.
LDR:04484nam 2200289 a 45 001 967224
005 20110915
008 110915s2007 eng d
035 $a (UnM)AAI3244807
035 $a AAI3244807
040 $a UnM $c UnM
100 1 $a Hu, Weiwei. $3 1291104
245 1 0 $a Characterization of hydrodynamic forces and interfacial phenomena in cell culture processes.
300 $a 176 p.
500 $a Adviser: Jeffrey J. Chalmers.
500 $a Source: Dissertation Abstracts International, Volume: 67-12, Section: B, page: 7211.
502 $a Thesis (Ph.D.)--The Ohio State University, 2007.
520 $a The maturity of biotechnology as a significant, commercial enterprise has led to the large scale production of products from a variety of cell types, including bacterial, fungal, mammalian, and microalgae. While both large scale (>10,000 L) mammalian cell culture and microalgae culture are currently used for commercial purposes, there still exist significant engineering challenges. One of these challenges is to quantify, and minimize, the effect of hydrodynamic forces on cells, which is in direct conflict with the ever pressing need to increase gas mass transfer capability and mixing performance of large scale bioreactors to improve productivity.
520 $a In this dissertation, a microfluidic channel was applied to quantitatively evaluate the effect of hydrodynamic forces on heterotrophic dinoflagellate Crypthecodinium cohnii, a naturally high producer of DHA. In the transient experiments, the lysis of C. cohnii cells was not observed even at high energy dissipation rate (EDR) of 5.8x10 7 W/m3, while a significant sub-lethal effect, the loss of flagellate, was identified at EDR higher than 1.6x10 7 W/m3. The flagellate can be regenerated approximately 45 minutes after exposure. During the "recovery process", the algae cells began to spin first, and then move in a straight direction. The presence of C. cohnii cells in bubble film and foam layer was also verified by microscopic observation. In the long-term experiments, the microfluidic channel was connected with a small stirred tank bioreactor, which facilitated repeated exposures of cells to high EDR. It was found that the growth of C. cohnii cells was not inhibited until an EDR of 5.9x10 6 W/m3 was achieved. This level was significantly higher than that in shaken flask experiments, where the shear stress was claimed to cause a negative effect on dinoflagellate proliferation by numerous published papers. Consequently, the limitation on oxygen mass transfer was identified to be a key issue in shaken flask cultures.
520 $a As has been well documented in the literature, bubble rupture typically creates significantly higher hydrodynamic forces than the forces created from impeller agitation. In this dissertation, two approaches were taken to minimize bubble-associate cell damage from gas sparging. The first approach consisted of mass screening surfactants to alleviate cell-bubble attachment. It was found that octyl-, nonyl-, and decyl-maltopyranoside were less toxic to Chinese hamster ovary (CHO) cells among twelve small molecule surfactants tested, and had no negative effect on cell growth in a chemical defined medium until a level around 0.2 times their critical micelle concentration (CMC) was achieved. Trends in the performance of these surfactants were explored based on the chemical structure as well as the dynamic surface tension. Finally, nonyl-maltopyranoside (NM) was identified as the most promising candidate, which can efficiently reduce the cell enrichment in the foam layer to a similar level to Pluronic F-68; a commonly used large molecule protective surfactant. The second approach to minimize bubble-associated cell damage was to develop an optimization strategy for aeration. A novel dual-sparger system was proposed based on theoretical calculations. These calculations suggest the use of microbubbles of oxygen and large bubbles of air to uncouple oxygen supplement and dissolved carbon dioxide removal, which has the potential to minimize the required aeration rates for mass transfer as well as cell damage by bubble rupture and foam problems in large scale bioreactors.
590 $a School code: 0168.
650 4 $a Biology, Cell. $3 1017686
650 4 $a Engineering, Chemical. $3 1018531
690 $a 0379
690 $a 0542
710 2 0 $a The Ohio State University. $3 718944
773 0 $t Dissertation Abstracts International $g 67-12B.
790 $a 0168
790 1 0 $a Chalmers, Jeffrey J., $e advisor
791 $a Ph.D.
792 $a 2007
856 4 0 $u http://pqdd.sinica.edu.tw/twdaoapp/servlet/advanced?query=3244807